Thread Rating:
  • 3 Vote(s) - 3.33 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Front Brake Calipers
Will a front brake caliper from a gl1200 interstate work on a gl1200 aspencade?
Honda part numbers are different.
Thanks
Bob
1984 Aspencade
Reply
#1 01-12-2010, 05:13 PM,
The thickness of the Aspencade rotor is substantially different from the Interstate because the Aspencade rotors are vented.
Since the pads are the same for all 1200's, I would suspect that the thickness difference is accounted for in the body of the caliper.
The perch offset may also be different. If you're buying off ebay or a vendor that's not local, I would suggest you buy a caliper specifically for your Aspencade.
Reply
#2 01-12-2010, 06:08 PM,
I installed 85 Aspencade rotors on a 84 Intertate. All I had to change were the mounting brackets. :d

Ride Safe, Don
Reply
#3 01-12-2010, 07:12 PM,
Thanks for the info. I'll just rebuild mine.

Bob
1984 Aspencade
Reply
#4 01-12-2010, 09:31 PM,
Do carefully inspect for corosion the grooves that the piston seals rest in... Quite often there is oxide in there that causes the seals to bind on the pistons... All the oxide must be completely removed else the pistons will once again bind in short order... Putting some calipar grease in the grooves will help prevent future oxide formations... The pistons should be easily installed with a little hand pressure only... If they feel tight at all then you need to recheck the grooves...
Ed Zogg
Reply
#5 01-14-2010, 05:56 PM,
Thanks for the tip Ed. I rebuilt the rear caliper last Winter when I replaced the rear rotor. After 4000 miles no problems so far.

Bob **==
1984 Aspencade
Reply
#6 01-15-2010, 01:08 PM,


Possibly Related Threads…
Thread Author Replies Views Last Post
  Can't get all the air out of Right Front Caliper brake line WingMan71 6 753 05-19-2017, 05:49 AM
Last Post: WingMan71
  Front brake problem bagelboy 4 1,252 05-11-2015, 08:35 PM
Last Post: bagelboy
  Brake Calipers SIR tricky 15 3,740 06-01-2014, 07:37 PM
Last Post: ironhead1970
  Front Brake Huge Improvement wilmas2cool 7 1,716 11-23-2013, 07:33 AM
Last Post: wingandaprayer
  1985 GL1200I Front Brake Bleed WAC1972 15 2,839 10-11-2013, 03:23 AM
Last Post: admin
  Front right brake problem charron.bob 1 555 04-21-2013, 04:32 PM
Last Post: charron.bob
  Front Brake Bleed gclave 3 623 01-26-2013, 03:42 PM
Last Post: gclave
  spongy front (hand) brake nascarnuts27 2 615 11-26-2011, 06:49 AM
Last Post: SIR tricky
  rebuilt calipers - now master cylinder problem 861200GW 5 903 03-19-2011, 06:09 AM
Last Post: unionjack
  front calipers lock up(thought i was inteligent) RodnStac 10 1,394 02-04-2011, 08:45 PM
Last Post: RodnStac

Forum Jump:


Users browsing this thread: 1 Guest(s)

Contact Us | GL1200 GOLDWINGS | Return to Top | | Lite (Archive) Mode | RSS Syndication
google-site-verification: googled4b4fe31e07b65d8.html