Thread Rating:
  • 4 Vote(s) - 2.5 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Rear shocks
Ok, need some help on the rear shock. I have one that the rubber boot is completely ripped apart, and the rear suspension wont hold air. I pumped it up before I left work, drove 30 miles, let it sit for half hour, and it was down to one bar on the gauge. Also there is a fluid leak in the back, and it looks like it is coming from the shock. Will replacing the shock solve all of these problems? And if so, does anyone have a step by step on how to replace it? I dont know much about these bikes, but its time I try to tackle something on them.
Reply
#1 04-05-2012, 05:22 AM,
the shock seals can be replaced which will stop the leaking but if the shocks have alot of miles then the best remedy is to replace the springs too,the seals are an easy replacement,the springs a little harder,best pictorial on seal and spring replacement is here:
<!-- m --><a class="postlink" href="http://www.goldwingfacts.com/forums/view_topic.php?id=14189&forum_id=1&highlight=gl1200+shocks">http://www.goldwingfacts.com/forums/vie ... 200+shocks</a><!-- m -->

for a bolt on replacement,progressive suspension has new units available and is a good value at about an average of $325
1987 Aspencade 129K
1986 SEI 93K
2014 Tri-Glide HD 17K

Hancock,MD
Reply
#2 04-05-2012, 05:58 AM,
If your gonna keep the bike for a while and want an improved ride and better handling, get the Progressives. Vast improvement !
Adam
'96 ST1100
Brewerton, NY
Reply
#3 04-05-2012, 06:10 AM,
Yes Progressives front and rear
They are old...... 25 years thereabouts
Did you get 25 years out of your car suspension?
The only stupid questions are the one's that are not asked.

Reply
#4 04-05-2012, 06:17 AM,
Thanks guys! If I were to replace the bad shock with progressive shock, do I just replace the one side, or should I do both sides on the back.
Reply
#5 04-05-2012, 07:05 AM,
you have to replace both shocks on the progressives,they require a different air hookup kit that adapts to their airline setup
1987 Aspencade 129K
1986 SEI 93K
2014 Tri-Glide HD 17K

Hancock,MD
Reply
#6 04-05-2012, 07:10 AM,
neoracer Wrote:the shock seals can be replaced which will stop the leaking but if the shocks have alot of miles then the best remedy is to replace the springs too,the seals are an easy replacement,the springs a little harder,best pictorial on seal and spring replacement is here:
<!-- m --><a class="postlink" href="http://www.goldwingfacts.com/forums/view_topic.php?id=14189&forum_id=1&highlight=gl1200+shocks">http://www.goldwingfacts.com/forums/vie ... 200+shocks</a><!-- m -->

for a bolt on replacement,progressive suspension has new units available and is a good value at about an average of $325

The bike has about 55,000 on it. Will replacing the seals fix both the fluid leak and the air leak?
Reply
#7 04-05-2012, 07:17 AM,
yes the shocks chamber the air in the same place as the fluid
[Image: VisitedStatesMap.jpg]
Reply
#8 04-05-2012, 09:11 PM,
BigDaddy12t Wrote:Ok, need some help on the rear shock. I have one that the rubber boot is completely ripped apart, and the rear suspension wont hold air. I pumped it up before I left work, drove 30 miles, let it sit for half hour, and it was down to one bar on the gauge. Also there is a fluid leak in the back, and it looks like it is coming from the shock. Will replacing the shock solve all of these problems? And if so, does anyone have a step by step on how to replace it? I dont know much about these bikes, but its time I try to tackle something on them.

At the shocks is not the only place the air can leak out. The air lines, fittings and the valve at the switch can all leak. The easiest way to check all this is to pump up the air pressure, use water and liquid soap in a spray bottle on the entire system and watch for bubbles. If the shocks are leaking I recommend a change up to Progressives because they make a fantastic difference on the GL1200.
Ed (Vic) Belanger - 1954-2015
Founder of gl1200goldwings.com

Reply
#9 04-06-2012, 04:45 AM,


Possibly Related Threads…
Thread Author Replies Views Last Post
  Rear Air Shocks goldwingrider 15 6,112 04-18-2015, 12:43 PM
Last Post: lucian
  Progressive rear shocks keystone373 11 4,703 08-10-2013, 03:42 AM
Last Post: wingandaprayer
  Rear shocks ship 4 2,317 01-29-2013, 10:46 AM
Last Post: ship
  All parts need to rebuild rear shocks. BigDaddy12t 12 5,211 07-06-2012, 02:20 PM
Last Post: Ed Z
  Oil in rear shocks Ofen 9 3,446 04-17-2012, 07:02 AM
Last Post: seabee
  Rear Shocks Bottoming Out JackH 14 4,786 02-02-2012, 06:27 AM
Last Post: wingandaprayer
  Inside the Rear Shocks delvis 11 4,269 01-14-2012, 10:23 PM
Last Post: 85GL1200I
  Good non-air rear shocks (progressive) RCB 11 4,430 09-29-2011, 08:08 AM
Last Post: RODNUT
  rear shocks, boy did I mess up waltharper 14 4,340 01-12-2011, 10:20 PM
Last Post: neoracer
  Progressive springs for rear shocks 10 3,909 10-02-2010, 03:10 PM
Last Post: BladeRunner

Forum Jump:


Users browsing this thread: 2 Guest(s)

Contact Us | GL1200 GOLDWINGS | Return to Top | | Lite (Archive) Mode | RSS Syndication
google-site-verification: googled4b4fe31e07b65d8.html